SUPERIOR Trikot-Flex

Flex Film: Polyurethane with Blockout Layer, 110 µ

In stock
As low as €18.88
excl. 19% VAT excl. Shipping and packaging
Grundpreis: €6.05 / 1 m
Please register or login. You can buy products only after successful activation of your account.

SUPERIOR

SUPERIOR TRIKOT-FLEX Flex Film for Polyester

SUPERIOR TRIKOT-FLEX is a flex film specially designed for lettering on tricots, football kit, soft shell jackets and other textiles made of polyester which tend to re-sublimate causing a standard flex film (heat transfer vinyl) to discolour.

Low press temperature only 130 °C.

Ecologically proven!
Ecologically proven and tested by the TÜV Rheinland according to the extended legal requiremants for textiles and leather products in the EU 11/2010 and also REACH relevant parameters. 


Tested for Harmful Substances

Instructions

Prepress garment for 1 second at full temperature before positioning the film. Wash inside out, wait 24 hours after the heat transfer.

Please note that the blockout layer in all blockout flex films can be damaged or destroyed by pressing the film at too high temperature or by numerous pressing.

Temperature
130 °C 

Time
15 sec. 

Pressure
Approx.
3,5 bar 
Remove Liner
Warm 
or cold
Second Pressing
No 

Washable at
60 °C 

Dry Cleaning
No 

These instructions are based on the values obtained from practical experience. No responsibility is taken for the correctness of this information. We strongly recommend the evaluation on test material.

Colours shown may deviate from the original colours and are for illustration purposes only!

Further Information

SUPERIOR TRIKOT-FLEX Blockout-Flex Film

SUPERIOR TRIKOT-FLEX is thinner and softer than other blockout or subli stop flex films for garment lettering. The flex film does not just feel better and is not as stiff as common blockout flex films but is also easier to use. The flex film (heat transfer vinyl) has more of a print character once pressed onto the textile and even small letters are easy to cut and weed (not suitable for lettering under 2 cm).

The SUPERIOR TRIKOT-FLEX is ideal for almost all delicate textiles due to the lower press temperature of only 130 °C and has a sticky liner for easier weeding. A special blockout layer prohibits a discolouring of the flex due to resublimation.

Resublimation

Tricots, jerseys, soft shell jackets and other polyester textiles can tend to resublimate where the pigment in the textile migrates into the flex film (heat transfer vinyl) causing it to discolour. This is caused by the pigment not being properly anchored in the textile. At foil direct we advise strongly against the use of standard flex films on polyester garments such as sportswear and soft shell jackets and recommend only the special blockout flex films such as the SUPERIOR TRIKOT-FLEX.